Inquiry for Self-Retracting Fall Arrester With 40mtr Wire Rope from Singapore
Keyword:Self-Retracting Fall Arrester Time:2021-3-4 11:27:57
Customer: Hi Kindly quote us best price as follows
01) Self-Retracting Fall Arrester With 40mtr Wire Rope – 04pcs
RAMHOIST: 325 USD/unit
it is with a sturdy aluminium alloy cover wrapped with a Plastic shell (外壳是合金外壳(铝合金)➕高强注塑外壳 )
Customer: Come with top the Ring
RAMHOIST: Now the Self-Retracting Fall Arrester is ready to deliery, below are site photos
24.6KG/package * 4 packages
Self retracting Fall Arrester with 40Mtr rope (with O ring in the top)
Customer: Problem happens as below:
I received feedback from my customer last time purchase fall Arrester 4pcs not working Properly
Fall Arrester Rope not go in properly
RAMHOIST: It is possible that the anti-dropping gear may be bumped during transportation, and a small spring inside the anti-dropping device will be biased and resist the double locks, causing the gear to not rotate and the wire rope to not be recycled.
Is it used on the side of the cruise ship to prevent the human body from falling at high altitude?
(这种40米的钢丝绳不回收, 可能在运输过程中防坠器发生摔碰,防坠器内部一个小弹簧发生偏位,顶住双锁止,导致齿轮不回转,从而导致钢丝绳不回收
这个防坠器是用于邮轮侧面,人体高空防坠的吗)
Customer:Yes
RAMHOIST: 1, See if the wire rope can be pulled. If it does, take the fall arrestor, place it on the ground, put it on its side, pull the wire rope to the end, and quickly retract the wire rope into the shell without hands Loosen, let the small spring return back.
2,This is the situation where the wire rope can be pulled out. Pull it to the end. If you can’t pull it, put the fall arrester on its side, pat the side of the fall arrester with your hand, pat the side of the fall arrester hard, pat 2 to 3 times, and then Pull and see to see if the wire rope can be pulled, if it still can’t be pulled, pat hard for several times. If it really doesn’t move, it can only be repaired by the factory.
(1,看看钢丝绳能不能拉的动,拉的动的话,把防坠器卸下来,放在地面上,侧过来放,把钢丝绳拉到头,迅速的让钢丝绳回缩进壳子里,手不要松,让小弹簧复位
2, 这是钢丝绳可以拉出来的情况,拉到头,如果不可以拉的话,把防坠器侧过来放,用手拍防坠器的侧面,使劲的拍,拍个2到3下,然后在拉拉看,看钢丝绳能不能拉得动,如果还拉不动得话,再使劲拍,连续几次拍,如果实在拍不动,只能是返厂维修了)
Customer: Need this type swivel Latching for the our future order
RAMHOIST: OK, see below
Customer:
Possible Housing can change Aluminium or steel Type ? Plastic very fast damaged also
Can but anything on layout ?
Something like that
New order this red color Guid also can install ?
RAMHOIST: yes, can install
Customer: OK Tq
RAMHOIST: we have two cover, inner cover is aluminum and outer cover is plastic cover, so with or without outer plastic cover it does not effect.
we found u use more than 200 times a day, right?
Customer: yes, Everyday use 15 Hrs
RAMHOIST: there is a steel ring in the cover and this time we will quench to make it harder and sturdier, lifer longer. normally the life for this is one year or 10000 times, see which come earlier, after quenching the steel ring, you can use 20000-30000 times. [钢丝绳出口处小铁圈加固淬火(使用太频繁)]
Customer: Normally no fall, anything happen only fall my Equipmend so the fall Arrester catch and save my equipment.
All the fall Arrester same problem the outcome small Ring damaged and can’t go in . Are you have any solution?
Can come out outside ?
RAMHOIST: The problem is use too much, the wire rope wears off the cover, the soluation is to replace the small steel ring in factory (使用频繁,钢丝绳磨掉外壳,要换下铁圈)but it is not realistic since there are too much freight cost between us.
your working codition is special, in this order we will make special treatment for the steel ring (quench to make it harder and sturdier, lifer longer).
the solution for the existing ones: Use an iron sheet or something to plug this wear out area, as long as it does not affect the stretch out and draw back of the wire rope, purpose is to prevent the wire rope from scraping (rubbing) the cover. scraping the cover will cause a result, that is, the wire rope will scrap the cover up and down, which will affect the speed of wire rope in and out.
(用个铁皮或什么东西塞在这个磨损处,只要不影响钢丝绳来回伸缩,就是防止钢丝绳磨这个壳子,磨这个壳子会导致一个结果,就是钢丝绳会沿着这个壳子上下摩擦,会影响钢丝绳的出绳速度和回缩速度,在这个地方搞个铁皮,圈一下)
Customer: I need The Rope Ferrule -100pcs can
Can send also ? For the 8MM wire rope.
RAMHOIST: for inserting 2 pcs of 8mm wire rope
Customer: Ok, Yes
RAMHOIST: 0.5usd/pc*100pcs=50 usd
5.5usd/kg*2kg=11 usd for express
Total: 61 USD
(中文叫铝套,100个1.4KG,2根8mm粗的钢丝绳能通过这个铝套压套,铝套就是穿2根的,不存在穿一根,穿一个要铝套就没意义了,就是把钢丝绳压个头,铝套就是起到连接2根钢丝绳的作用,把2根钢丝绳连接在一起,)
铝套用在钢丝绳上,也不一定非要防坠器上,钢丝绳上都可以用,防坠器上也有
RAMHOIST: Site photos of Self-Retracting Fall Arrester for 2nd order (do some change above based on 1st order)
2021/11/16
Customer: Hi Kindly Quote us best price as follows
01) Self-Retracting Fall Arrester With 40mtr Wire Rope 100kg – 08PCS
RAMHOIST: PI has been sent to your email
Problem happens:
Customer: Your fall Arrester all not working properly so need to change your quality
For this New order 8pcs before you proceed try Other quality and good working conditions
Your fall Arrester all pulled my equipment
Please this new order you try other quality
(你的防坠器都不能正常工作, 所以需要改变你的质量
对于此新顶订单 8 件,请在制造之前尝试其他质量和良好工作状况
你的防坠落器都拉了我的装备
这个新订单请尝试其他质量。
Customer: Dear Sir,
Kindly add above attached all the Certificates EN360 : 2002 Standard, Required in Singapore for Usages the Fall arresters
RAMHOIST: Pls check below
Wire rope and spring need to replace by stainless steel when used in marine enviroment